服務熱線:
400-879-1999
欄目導航
聯系我們
服務熱線
400-879-1999
電話:400-879-1999
地址:山東省萊州市206國道與308省道交叉口東南50米
當前位置:首頁 > 攪拌車資訊 > 行業動態 > 中科攪拌機車皮帶維修方法有哪些?
中科攪拌機車皮帶維修方法有哪些?
來源:http://www.wtiqradio.com發布日期:2021-01-11   瀏覽量:
 
攪拌車修針對發動機皮帶磨損和預防老化,都有定義的,在定義機前端罕見根皮帶,各個皮帶都承擔著首要的結果。在提議機上,經由皮帶傳動驅動各類輔機運轉。假設中科攪拌車的皮帶斷裂了,或許出現了打滑,都將使相關的輔機損掉功用,或使其功用下降,然后影響到攪拌車的正常運用。
Mixer repair for the engine belt wear and aging prevention, have a definition, in the definition of the front end of the rare belt, each belt bears the primary result. On the machine, all kinds of auxiliary machines are driven by belt drive. Assuming that the belt of Zhongke mixer is broken or slipping, the function of relevant auxiliary machinery will be lost or its function will be reduced, and then the normal operation of mixer will be affected.
皮帶的反省方法十分簡單。首先反省皮帶的張力,這時可以用拇指,強力地按壓2個皮帶輪中間的皮帶。按壓力約為10kg左右,假設皮帶的壓下量在 10mm左右,則認為皮帶張力敲適合。假設壓下量過大,則認為皮帶的張力缺乏。假設皮帶幾乎不出現壓下量,則認為皮帶的張力過大。張力缺乏時,皮帶很隨便出現打滑。張力過大時,很隨便損傷各類輔機的軸承。為此,應該把相關的調整螺母或螺栓擰松,把皮帶的張力調整到的形狀。
The method of introspection is very simple. First, check the tension of the belt. At this time, press the belt between the two pulleys with your thumb. According to the pressure of about 10kg, assuming that the reduction of the belt is about 10mm, it is considered that the belt tension is suitable. If the reduction is too large, the belt tension is considered to be insufficient. If there is almost no reduction in the belt, it is considered that the tension of the belt is too large. When there is a lack of tension, the belt slips easily. When the tension is too large, it is easy to damage the bearings of various auxiliary machines. Therefore, the relevant adjusting nuts or bolts should be loosened to adjust the tension of the belt to the best shape.
除此之外,中科攪拌車維修還必需留心皮帶的磨損情況。舊皮帶磨損嚴肅,使皮帶和皮帶輪的接觸面積銳減。這時只需用力一壓皮帶,皮帶就深深地下沉到皮帶輪的槽內。皮帶的橡膠還有一個老化問題,假設皮帶橡膠嚴肅老化,必需及時地改換新皮帶。
In addition, the maintenance of Zhongke mixer must pay attention to the wear of the belt. The old belt is seriously worn, so that the contact area between belt and pulley is sharply reduced. At this time, just press the belt hard, and the belt will sink deeply into the groove of the pulley. There is also an aging problem for the rubber of the belt. Assuming that the rubber of the belt is seriously aging, it is necessary to replace the belt in time.
中科攪拌車發動機是汽車腦部,如果發動機壞,就等于一部汽車都沒,攪拌車每天到要在馬路上奔跑,時間長的話,可能會導致混凝土攪拌罐發動機皮帶磨損或者老化,所以司機一般過一段時間,就要開始檢查皮帶,以免造成不必要的麻煩。
The engine of Zhongke mixer is the brain of the car. If the engine is broken, it means that there is no car. The mixer has to run on the road every day. If it takes a long time, it may lead to the wear or aging of the engine belt of the concrete mixer. Therefore, the driver usually starts to check the belt after a period of time, so as not to cause unnecessary trouble.
?

萊州中科聚峰機械有限公司
電話:15053524111 地址:山東省萊州市206國道與308省道交叉口東南50米
聚峰機械專注生產銷售混凝土全自動攪拌車,小型混凝土自動攪拌車,自進料混凝土攪拌車,平口攪拌車,廠家直銷,型號齊全,經久耐用,質優價廉;以規范的管理為依托,以專業的技術為支持,安全可靠,讓您放心選擇!

欧美精品中文字幕一区