服務熱線:
400-879-1999
欄目導航
聯系我們
服務熱線
400-879-1999
電話:400-879-1999
地址:山東省萊州市206國道與308省道交叉口東南50米
當前位置:首頁 > 攪拌車資訊 > 行業動態 > 小型混凝土攪拌機的配料順序是多少?
小型混凝土攪拌機的配料順序是多少?
來源:http://www.wtiqradio.com發布日期:2021-07-28   瀏覽量:
 
1.小型混凝土攪拌車整機到貨后,應按照裝箱清單清點所帶配件及技術文件是否齊全,檢查整機零件有無缺損;
1. After the small concrete mixer arrives, check whether the accessories and technical documents are complete according to the packing list, and check whether the parts of the whole machine are defective;
2.用戶須根據所購產品的基礎圖打好基礎;
2. Users must lay a good foundation according to the foundation drawing of the purchased products;
3.俺按基礎圖的安裝位置就位,使各機構處于水平狀態;
3. I shall be in place according to the installation position of the foundation drawing to make each mechanism in a horizontal state;
4.配料整機就為后,裝上傳感器,拆去稱料斗固定螺栓,使稱料斗處于正常工作狀態;
4. After the concrete batching machine is complete, install the sensor and remove the fixing bolts of the weighing hopper to make the weighing hopper in normal working state;
5.檢查各傳動部分是否靈活,各連接部位螺栓是否松動;
5. Check whether the transmission parts are flexible and whether the bolts at each connecting part are loose;
6.按《配料控制儀說明書》進行電氣線路的接連安裝,其中包括:主電源電纜和各個電動機電纜、傳感器電纜和遙控器電纜;
6. Connect and install the electrical lines according to the specification of batching controller, including main power cable, each motor cable, sensor cable and remote control cable;
7.進行空車運轉試驗,檢查各電動機的轉向是否正確;
7. Conduct no-load operation test and check whether the steering of each motor is correct;
8.俺配料控制儀說明書的要求,進行模擬配料循環試驗,對各種物料進行小稱量設定,檢查其能否進行自動循環配料。
8. According to the requirements of the manual of the batching controller, carry out the simulated batching cycle test, set the small weighing of various materials, and check whether they can carry out automatic cyclic batching.
特別注意:
Special attention:
1.總電源到電器箱之間應設置閘刀;
1. Knife switch shall be set between the main power supply and the electrical box;
2.配料控制儀電源零線決不允許與地線接錯,否則將出現嚴重事故;
2. The zero line of the power supply of the batching controller must not be wrongly connected with the ground wire, otherwise serious accidents will occur;
3.配料控制儀要可靠接地,電阻不大于4歐姆;
3. The batching controller shall be reliably grounded, and the resistance shall not be greater than 4 ohms;
4.配料控制儀放置位置應架設防曬、防雨、防塵、防雷等設施。
4. Sunscreen, rainproof, dustproof, lightning protection and other facilities shall be erected at the placement position of batching controller.
?

萊州中科聚峰機械有限公司
電話:15053524111 地址:山東省萊州市206國道與308省道交叉口東南50米
技術支持:網站建設·推廣運營
聚峰機械專注生產銷售混凝土全自動攪拌車,小型混凝土自動攪拌車,自進料混凝土攪拌車,平口攪拌車,廠家直銷,型號齊全,經久耐用,質優價廉;以規范的管理為依托,以專業的技術為支持,安全可靠,讓您放心選擇!

欧美精品中文字幕一区