服務熱線:
400-879-1999
聯系我們
服務熱線
400-879-1999
電話:400-879-1999
地址:山東省萊州市206國道與308省道交叉口東南50米
當前位置:首頁 > 攪拌車資訊 > 新聞資訊 > 使用自上料攪拌車哪些問題應該避免?
使用自上料攪拌車哪些問題應該避免?
來源:http://www.wtiqradio.com發布日期:2020-05-07   瀏覽量:
 
1、自上料攪拌車應設置在平整的方位,用方木墊起前后輪軸,使輪胎擱高架空,避免在開動時發作走動。
1. The self loading mixer shall be set in a flat position, and the front and rear axles shall be padded with square wood, so that the tire can be put on the elevated space, so as to avoid moving when starting.
2、自上料攪拌車應施行級漏電保護,上班前電源接通后,有必要仔細查看,經空車試轉以為合格,方可運用。試作業時應查驗拌筒轉速是否適宜,一般狀況下,空車速度比重車(裝料后)稍快2~3轉,如相差較多,應調整動輪與傳動輪的份額。
2. Since the charging mixer shall be provided with level leakage protection, it is necessary to check it carefully after the power supply is connected before going to work, and it can be used only after the test run of the empty mixer is qualified. During trial operation, it is necessary to check whether the speed of mixing drum is appropriate. Generally, the speed of empty truck is slightly faster than that of loaded truck by 2-3 revolutions. If there is a large difference, the share of driving wheel and driving wheel shall be adjusted.
3、拌筒的旋轉方向應契合箭頭指示方向,如不符實,應更正電機接線。
中科自上料攪拌車
3. The rotation direction of the mixing drum shall match the direction indicated by the arrow. If not, the motor wiring shall be corrected.
4、查看傳動離合器和制動器是否靈敏牢靠,鋼絲繩有無損壞,軌跡滑輪是否杰出,周圍有無妨礙及各部位的光滑狀況等。
4. Check whether the transmission clutch and brake are sensitive and reliable, whether the steel wire rope is damaged, whether the track pulley is outstanding, whether there are obstacles around and the smooth condition of each part, etc.
5、開機后,常常留意混凝土攪拌機各部件的作業是否正常。停機時,常常查看混凝土攪拌機葉片是否打彎,螺絲有否打落或松動。
5. After start-up, always pay attention to whether the operation of each part of the concrete mixer is normal. When the machine is stopped, always check whether the blade of the concrete mixer is bent and whether the screw is broken or loose.
6、當混凝土拌和結束或估計停歇1h以上,除將余料出凈外,運用石子和清水倒入抖筒內,開機滾動,把粘在料筒上的砂漿沖刷潔凈后悉數卸出。料筒內不得有積水,避免料筒和葉片生銹。一起還應整理拌和筒外積灰,使機械保持清潔無缺。
6. When the concrete mixing is finished or the rest is estimated to be more than 1h, in addition to discharging the surplus materials, use stones and clear water to pour into the shaking cylinder, start the machine and roll, wash and clean the mortar stuck on the cylinder, and then discharge it. There shall be no ponding in the barrel to avoid rusting of the barrel and blades. At the same time, the ash outside the mixing drum shall be cleaned to keep the machinery clean.
7、下班后及停機不用時,應拉閘斷電,并鎖好開關箱,以確保安全。
7. After work and when the machine is not in use, the power shall be cut off and the switch box shall be locked to ensure safety.
?

萊州中科聚峰機械有限公司
電話:15053524111 地址:山東省萊州市206國道與308省道交叉口東南50米
聚峰機械專注生產銷售混凝土全自動攪拌車,小型混凝土自動攪拌車,自進料混凝土攪拌車,平口攪拌車,廠家直銷,型號齊全,經久耐用,質優價廉;以規范的管理為依托,以專業的技術為支持,安全可靠,讓您放心選擇!

日本无吗无卡v免费清高清