服務熱線:
400-879-1999
欄目導航
聯系我們
服務熱線
400-879-1999
電話:400-879-1999
地址:山東省萊州市206國道與308省道交叉口東南50米
當前位置:首頁 > 攪拌車資訊 > 新聞資訊 > 為什么小型混凝土自動攪拌車前部鋼板容易斷裂?
為什么小型混凝土自動攪拌車前部鋼板容易斷裂?
來源:http://www.wtiqradio.com發布日期:2021-05-07   瀏覽量:
 
小型混凝土自動攪拌車的前鋼板由9個零件組成。許多人報告說,混凝土自動攪拌車的上一部分和下一部分在使用過程中很容易折斷,這是什么原因?
The front steel plate of small-sized automatic concrete mixer consists of 9 parts. Many people report that the upper part and the lower part of the automatic concrete mixer are easy to break during use. What is the reason?
(1)過度使用緊急制動器。在上坡駕駛時,在下坡道路上使用緊急制動會導致前鋼板斷裂。由于制動力的作用,混凝土自動攪拌車的大部分負載質量都會被前板簧推動并承受,這很容易造成板簧的疲勞損壞。建議使用排氣制動器以減少緊急制動。
(1) Excessive use of emergency brakes. When driving uphill, the use of emergency brake on downhill road will lead to the fracture of front steel plate. Because of the braking force, most of the load mass of the automatic concrete mixer will be pushed and borne by the front leaf spring, which is easy to cause the fatigue damage of the leaf spring. Exhaust brake is recommended to reduce emergency braking.
(2)前輪制動器調節太緊。如果后輪制動性能不佳或發生突然問題,請施加緊急制動以過度沖擊破壞前片簧。
(2) Front wheel brake adjustment too tight. If the rear wheel braking performance is poor or there is a sudden problem, please apply emergency braking to damage the front leaf spring by excessive impact.
小型混凝土自動攪拌車
(3)路面不好,超載,超速,前板簧受力過大,容易造成損壞。
(3) Bad road, overload, overspeed, front leaf spring stress is too large, easy to cause damage.
(4)前板簧經常長時間過載,彈性和剛度降低,疲勞受損。
(4) The front leaf spring is often overloaded for a long time, the elasticity and stiffness are reduced, and the fatigue is damaged.
(5)如果更換質量較差的板簧,則葉片的曲率不符合標準。鋼材不好或熱處理不好會導致應力不均和斷裂。
(5) If the leaf spring with poor quality is replaced, the curvature of the blade does not meet the standard. Poor steel or heat treatment will lead to uneven stress and fracture.
為了防止混凝土自動攪拌車的前板簧的上一塊和下一塊自動加載,建議采用以下方法:
In order to prevent the front leaf spring of automatic concrete mixer from loading automatically, the following methods are recommended:
(1)檢查并保持準時,以確保片簧潤滑良好,并正確調節了車輛的制動器。
(1) Check and be punctual to ensure that the leaf springs are well lubricated and the brakes of the vehicle are properly adjusted.
(2)少用緊急制動,多用發動機排氣制動,載荷均勻,無偏差,但不超載。
(2) Less use of emergency brake, more use of engine exhaust brake, uniform load, no deviation, but not overload.
(3)更換前鋼板刀片時,一定使用優良鋼板以確保彎曲度符合要求。
(3) When replacing the blade of front steel plate, be sure to use excellent steel plate to ensure that the bending meets the requirements.
小型混凝土自動攪拌車的鋼板斷裂問題介紹就是這些,你明白了嗎?想要了解更多可以直接關注:http://www.wtiqradio.com
This is the introduction of steel plate fracture of small concrete mixer. Do you understand? If you want to know more, you can pay attention to: http://www.wtiqradio.com
?

萊州中科聚峰機械有限公司
電話:15053524111 地址:山東省萊州市206國道與308省道交叉口東南50米
聚峰機械專注生產銷售混凝土全自動攪拌車,小型混凝土自動攪拌車,自進料混凝土攪拌車,平口攪拌車,廠家直銷,型號齊全,經久耐用,質優價廉;以規范的管理為依托,以專業的技術為支持,安全可靠,讓您放心選擇!

日本无吗无卡v免费清高清