服務熱線:
400-879-1999
欄目導航
聯系我們
服務熱線
400-879-1999
電話:400-879-1999
地址:山東省萊州市206國道與308省道交叉口東南50米
當前位置:首頁 > 攪拌車資訊 > 常見問題 > 一輛攪拌車怎樣檢驗才算合格?
一輛攪拌車怎樣檢驗才算合格?
來源:http://www.wtiqradio.com發布日期:2020-05-14   瀏覽量:
 
一、整車的外廓尺寸應符國家標準的規定。并按批準的產品圖樣及技術文件制造。
1、 The overall dimensions of the whole vehicle shall conform to the provisions of national standards. It shall be manufactured according to the approved product drawings and technical documents.
二、外購件、外協件均應有制造廠的產品合格證,并符合相關標準的要求,經攪拌車生產廠檢驗合格后方可裝配。
2、 Purchased parts and outsourced parts shall be provided with the product certificate of the manufacturer and meet the requirements of relevant standards. They can be assembled only after passing the inspection of the mixer manufacturer.
三、攪拌車的廠定大總質量不得超過底盤的大許用值,轉向軸(輪)載質量和側傾穩定角應符合GB7258的規定。
3、 The factory determined total mass of the mixer shall not exceed the allowable value of the chassis, and the steering shaft (wheel) load mass and roll stability angle shall comply with the provisions of GB7258.
點擊進入看圖評論
Click to view the comments
四、焊縫應均勻、平直。無漏焊、裂紋、央渣、表面應無毛邊,包砂等現象。
4、 The weld shall be even and straight. There shall be no missing welding, crack, slag, rough edge and sand inclusion on the surface.
中科聚峰廠家
五、所有外露黑色金屬表面均應作防銹處理。外表裝飾漆應美觀大方,符合GB7258的規定。
5、 All exposed ferrous metal surfaces shall be rust proof. The exterior decorative paint shall be beautiful and generous, and conform to the provisions of GB7258.
六、從進料到輸送卸料完畢,允許的長時間為90mh,且攪拌筒按規定連續運輸不大于300轉。攪拌車行駛時,高車速不得超過如50km/h
6、 The allowable long time from feeding to unloading is 90mh, and the continuous transportation of the mixing drum is no more than 300 revolutions according to the regulations. When the mixer is running, the high speed shall not exceed 50km / h
七、裝入預拌混凝土在規定的攪動轉速和輸送時間運送到交貸地點后,泥凝土質量應符國標要求。
7、 After the ready mixed concrete is loaded and transported to the delivery place at the specified agitation speed and delivery time, the quality of the mud concrete shall meet the requirements of the national standard.
八、進料斗出口尺寸不小于歷650mm,距地面高度應不大于3.8m。
8、 The outlet size of the feed hopper shall not be less than 650mm, and the height from the ground shall not be more than 3.8m.
九、水泥攪拌車的出料速度不小于0.65m3/min,出料殘余率小于2-5%。攪拌車的進料速度不小于2.7m3/min
9、 The discharging speed of cement mixer shall not be less than 0.65m3/min, and the discharging residual rate shall be less than 2-5%. The feeding speed of the mixer shall not be less than 2.7m3/min
十、輸送應安裝牢固。各連接部分部件不應有損壞、變形等現象,不應有上車與底盤偏離原先的固定裝置的情況。
10、 The conveying shall be installed firmly. All connecting parts shall be free of damage, deformation and other phenomena, and there shall be no deviation between the upper carriage and the chassis from the original fixed device.
十一、車在大總質量狀態下,以20km/h的速度府能通過14%的坡道外溢。
11、 Under the condition of large total mass, the vehicle can pass 14% of the ramp at the speed of 20km / h.
十二、制動性能府符合國標規定。行駛車外噪聲應符國標要求。
12、 The brake performance meets the national standard. The noise outside the driving vehicle shall meet the requirements of the national standard.
十三、整車的各項密封性能良好,各密封面、管接頭及所有連接部位均不得有滲油漏氣的現 象。
13、 The sealing performance of the whole vehicle is good, and all sealing surfaces, pipe joints and all connecting parts shall be free of oil leakage.
本文來自:中科聚峰廠家更多的內容請點擊:http://www.wtiqradio.com我們將會為您提問的問題提供一個滿意的服務,歡迎您的來電!
This article comes from: Zhongke Jufeng factory more content please click: http://www.wtiqradio.com we will provide a satisfactory service for your questions, welcome your call!
?

萊州中科聚峰機械有限公司
電話:15053524111 地址:山東省萊州市206國道與308省道交叉口東南50米
聚峰機械專注生產銷售混凝土全自動攪拌車,小型混凝土自動攪拌車,自進料混凝土攪拌車,平口攪拌車,廠家直銷,型號齊全,經久耐用,質優價廉;以規范的管理為依托,以專業的技術為支持,安全可靠,讓您放心選擇!

日本无吗无卡v免费清高清