服務熱線:
400-879-1999
欄目導航
聯系我們
服務熱線
400-879-1999
電話:400-879-1999
地址:山東省萊州市206國道與308省道交叉口東南50米
當前位置:首頁 > 攪拌車資訊 > 常見問題 > 混凝土自動攪拌車發動機使用錯誤講解!
混凝土自動攪拌車發動機使用錯誤講解!
來源:http://www.wtiqradio.com發布日期:2021-05-28   瀏覽量:
 
些特定的混凝土全自動攪拌車司機認為發動機溫度不低,因此發動機恒溫器將被自動移除,而冷 卻液只能從夜間循環中移除。由于無法調節冷 卻強度,因此發動機通常在高溫條件下運行。這會導致磨損并增加燃油消耗。實際上,高溫對發動機有害。為了確保發動機的使用壽命,應將安裝自動混凝土攪拌車的用例限 制在環境溫度范圍內。
Some specific concrete mixer drivers think that the engine temperature is not low, so the engine thermostat will be automatically removed, and the coolant can only be removed from the night cycle. Because the cooling intensity cannot be adjusted, the engine usually runs at high temperature. This causes wear and increases fuel consumption. In fact, high temperature is harmful to the engine. In order to ensure the service life of the engine, the use case of installing the automatic concrete mixer should be limited to the ambient temperature range.
混凝土自動攪拌車
橡皮筋很好。如果皮帶太松,不僅會拉伸并損壞皮帶,縮短皮帶的使用壽命,而且過大的壓力會自動加載并扭曲攪拌器的發電機軸和泵軸,從而損壞攪拌器。為了滿足技術要求,一定松開自動混凝土攪拌車的風扇皮帶。建議的組裝偏差為10-15毫米。
The rubber band is very good. If the belt is too loose, it will not only stretch and damage the belt, shorten the service life of the belt, but also the excessive pressure will automatically load and twist the generator shaft and pump shaft of the agitator, thus damaging the agitator. In order to meet the technical requirements, the fan belt of the automatic concrete mixer must be loosened. The recommended assembly deviation is 10-15mm.
許多駕駛員知道這輛車剛剛起步。同樣,如果發動機轉速過低,則由于打滑不好會損壞發動機。
Many drivers know that the car is just starting. Similarly, if the engine speed is too low, the engine will be damaged due to poor slip.
但是,大多數人都知道自動混凝土攪拌車中的油泵無法快速潤滑光滑表面上的潤滑劑,因為由于加熱速度較慢,它們將在短時間內處于閑置狀態。同時,由于高溫燃油霧化不足,燃燒的燃油進入曲軸箱,沖刷了氣缸壁上的油膜,并加速了零件的磨損。因此,在自潤滑發動機啟動后幾秒鐘的高溫條件下,有必要改 善空轉加熱并提高發動機滑移率。
However, most people know that the pumps in the automatic concrete mixer cannot quickly lubricate the lubricant on the smooth surface, because they will be idle for a short time due to the slow heating speed. At the same time, due to the lack of high temperature fuel atomization, the burning fuel enters the crankcase, washes the oil film on the cylinder wall, and accelerates the wear of parts. Therefore, it is necessary to improve the idling heating and increase the slip ratio of the self-lubricating engine in the high temperature condition of a few seconds after starting.
?

萊州中科聚峰機械有限公司
電話:15053524111 地址:山東省萊州市206國道與308省道交叉口東南50米
聚峰機械專注生產銷售混凝土全自動攪拌車,小型混凝土自動攪拌車,自進料混凝土攪拌車,平口攪拌車,廠家直銷,型號齊全,經久耐用,質優價廉;以規范的管理為依托,以專業的技術為支持,安全可靠,讓您放心選擇!

日本无吗无卡v免费清高清