服務熱線:
400-879-1999
欄目導航
聯系我們
服務熱線
400-879-1999
電話:400-879-1999
地址:山東省萊州市206國道與308省道交叉口東南50米
當前位置:首頁 > 攪拌車資訊 > 常見問題 > 水泥攪拌車罐體停轉故障緊急處理措施
水泥攪拌車罐體停轉故障緊急處理措施
來源:http://www.wtiqradio.com發布日期:2022-05-26   瀏覽量:
 
水泥攪拌車出現問題沒有招?只能眼睜睜的看著混凝土凝固,這是多么讓人著急上火的事。但現在你不用再擔心了,因為攪拌車廠家-攪拌車專家為您量身定做一套解決方案,有了它,再也不用擔心事故啦!
There is no solution to the problem of cement mixer? Can only watch the concrete solidify, how anxious and angry it is. But now you don't have to worry, because the mixer manufacturer - mixer experts tailor a set of solutions for you. With it, you don't have to worry about accidents anymore!
一、 罐體轉動工作原理
1、 Working principle of can body rotation
發動機取力器——傳動軸——油泵——馬達——減速機——罐體轉動
Engine power take-off - transmission shaft - oil pump - motor - reducer - can body rotation
二、原因分析
2、 Cause analysis
導致攪拌罐停轉主要有以下原因:
The main reasons for the shutdown of the mixing tank are as follows:
1. 發動機故障:發動機無法啟動、取力器損壞等原因。
1. Engine failure: the engine cannot be started, the power take-off is damaged, etc.
2. 上裝故障:傳動軸損壞、油泵故障、液壓油過臟或油量不足、馬達故障、減速機故障、操縱桿松脫等原因。
2. Mounting failure: transmission shaft damage, oil pump failure, dirty or insufficient hydraulic oil, motor failure, reducer failure, control lever loosening and other reasons.
三、尋找故障點
3、 Find the fault point
當車輛運送混凝土過程中,發生罐體無法轉動故障,應停車進行檢查。通過“一聽、一看、一動”迅速尋找故障點,“一聽”是指從傳動軸到減速機各零部件有無發出異響;“一看”是指看液壓油箱油位是否過低或管路漏油嚴重;“一動”是指前后扳動油泵伺服桿,罐體是否正反均無轉動。
When the tank fails to rotate during the transportation of concrete, the vehicle shall be stopped for inspection. Quickly find the fault point by "listening, looking and moving". The "listening" refers to whether the parts from the transmission shaft to the reducer make abnormal noise; "One look" means to check whether the oil level of the hydraulic oil tank is too low or the pipeline leaks seriously; "Movement" refers to pulling the oil pump servo rod back and forth, and whether the tank body does not rotate in both positive and negative directions.
注:應在罐體停止轉動后當即聯系當地服務人員(附通訊錄),告知罐內混凝土標號及預凝時間,服務人員會耐心指導您如何處理,同時請您將車輛開至就近服務站。
Note: after the tank stops rotating, immediately contact the local service personnel (with address book) to inform the concrete label and pre setting time in the tank. The service personnel will patiently guide you how to deal with it. At the same time, please drive the vehicle to the nearest service station.
四、應急措施
4、 Emergency measures
如果不能在混凝土預凝之前將車輛修復,應立即采取應急措施:
If the vehicle cannot be repaired before the concrete is pre set, emergency measures shall be taken immediately:
1. 馬達和減速機無故障情況下,連接“應急油管”將混凝土卸出,預防凝灌事故發生。
1. Connect the "emergency oil pipe" to unload the concrete when the motor and reducer have no fault, so as to prevent concreting accidents.
2. 馬達或減速機發生故障且確定無法在混凝土預凝前使罐體轉動,請快速打開人孔蓋,如人孔蓋不在罐體下方則需要在罐體前錐底部開孔(Φ=1250px,避開原有焊道),與此同時持續向進料口灌入大量清水,沖刷罐內混凝土,直至罐體下方無混凝土流出,罐內少量殘余混凝土需人工進行清理,清理完畢后進行清洗,將割下部分重新焊接到罐體上(安裝人孔蓋),并打磨噴漆處理
2. If the motor or reducer fails and it is determined that the tank cannot rotate before the concrete is pre set, please quickly open the manhole cover. If the manhole cover is not below the tank, you need to open a hole at the bottom of the front cone of the tank( Φ= 1250px, avoiding the original weld bead), and at the same time, continuously pour a large amount of clean water into the feed inlet to wash the concrete in the tank until no concrete flows out under the tank. A small amount of residual concrete in the tank needs to be cleaned manually. After cleaning, the cut part shall be welded to the tank again (install manhole cover), and polished and painted
本文的精彩內容由混凝土全自動攪拌車提供知識提供,本網站還有很多的精彩內容,更多的內容您可以點擊進入:http://www.wtiqradio.com我們有專門的客服為您解答問
The wonderful content of this article is provided by the concrete automatic mixer. There are many wonderful contents on this website. You can click to enter more contents: http://www.wtiqradio.com We have special customer service to answer your questions

萊州中科聚峰機械有限公司
電話:15053524111 地址:山東省萊州市206國道與308省道交叉口東南50米
技術支持:網站建設·推廣運營
聚峰機械專注生產銷售混凝土全自動攪拌車,小型混凝土自動攪拌車,自進料混凝土攪拌車,平口攪拌車,廠家直銷,型號齊全,經久耐用,質優價廉;以規范的管理為依托,以專業的技術為支持,安全可靠,讓您放心選擇!

<蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <蜘蛛词>| <文本链> <文本链> <文本链> <文本链> <文本链> <文本链>